Ideal Garage Door Spring Installation

3 thread the lifting cables onto the spring.

Ideal garage door spring installation.

Keep in mind that a long metal spring is being stretched to the point that it will lift your entire garage door which can weigh several hundred pounds. Screw the holding brackets above the garage door opening then rest the spring s metal ends on top of the brackets. Check the owner s manual included in the spring kit for directions on how to thread the cables. Ideal garage doors have been an american made garage door manufacture for over 30 years located in mason ohio.

If the garage door won t stay on the floor and if it pulls itself up when stopped halfway close the door and remove 1 4 turn of tension from the spring. Ideal door is a leader in residential and commercial garage doors and a preferred brand among consumers architects specifiers and building professionals. The wood anchor pad must be made of a grade 2 or better southern yellow pine also known as southern pine or yellow pine. It covers installation of extension springs step 14 of the manual.

Many motorized garage door openers are equipped with a. Step 1 lift door. For all other information and safety warnings concerning your garage door see the manual. To install a new garage door spring you will first need to know the type of spring it uses.

One at each corner. Ideal is known for the innovative contributions to the garage door industry with the saf t bracket bottom bracket and the ez set spring system. Read the information in both manuals before beginning. Once you figure that out you can install the new one.

Step by step replacement of extension springs must be done with caution. Extension spring and torsion spring are the two types of garage door springs. Step 1 preparing the door frame it is important that the torsion spring assembly be firmly and securely attached to the frame of the garage. The four fasteners must be installed no closer than 1 1 2 from the sides and the ends of the anchor pad.

Add 1 4 turn of tension to the spring if the door will drop to the floor by itself from the halfway point. Lift the door to a fully open position. Extension spring installation this is a supplement to the residential garage door instructions referred to as the manual. Broken garage door extension springs make it difficult to open your garage door.

Get in touch 1 800 621 3667. A broken spring can prevent an electric door opener s motor from reaching top speed so a slowly moving door could be a symptom of a spring issue. Door opens and closes too slowly. The door should stay down when closed halfway when opened halfway and open when opened.